|
346075427
|
1032500
|
2022-07-13
|
805 W 3RD S., SUGAR CITY, ID, 83448
|
|
| Inspection Type |
Complaint
|
| Scope |
Partial
|
| Safety/Health |
Safety
|
| Close Conference |
2022-07-13
|
| Case Closed |
2023-04-19
|
Related Activity
| Type |
Complaint |
| Activity Nr |
1914831 |
| Safety |
Yes |
|
Violation Items
| Citation ID |
01001A |
| Citaton Type |
Other |
| Standard Cited |
5A0001 |
| Issuance Date |
2022-12-06 |
| Abatement Due Date |
2023-01-25 |
| Current Penalty |
13674.0 |
| Initial Penalty |
13674.0 |
| Final Order |
2023-01-10 |
| Nr Instances |
1 |
| Nr Exposed |
3 |
| Related Event Code (REC) |
Complaint |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
OSH ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to struck-by and crushing hazards while storing and retrieving totes from an industrial rack system that had damage, was not secured to the floor or formally inspected periodically: a) On July 13, 2022, and times prior, components of the Unarco drive-in rack system in the new freezer, used for the storage of potato product totes, were damaged. This damage included but may not be limited to bent or twisted "Z" rails, support "T" brackets and cracked sloped upright columns. b) On July 13, 2022, and times prior the support columns on the Unarco drive-in rack system in the new freezer, used for the storage of potato product totes, were not anchored to the floor. c) On July 13, 2022, and times prior comprehensive, periodic inspections were not being conducted on the Unarco drive-in rack system in the new freezer. Note) Certification of corrective actions are required for these items. |
|
| Citation ID |
01001B |
| Citaton Type |
Other |
| Standard Cited |
19100176 B |
| Issuance Date |
2022-12-06 |
| Abatement Due Date |
2023-01-25 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2023-01-10 |
| Nr Instances |
1 |
| Nr Exposed |
3 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.176(b): Storage of material created a hazard. Bags, containers, bundles, etc., stored in tiers were not stacked, blocked, interlocked and limited in height so that they were stable and secure against sliding or collapse. a) On July 13, 2022, and at times prior, product totes stored on the floor in the old freezer are not secured from falling over or collapsing. Wooden pallets between totes and posts on the interior corners of the totes were damaged. Note) Certification of corrective action is required for this item. |
|
| Citation ID |
01002 |
| Citaton Type |
Other |
| Standard Cited |
19100037 A03 |
| Issuance Date |
2022-12-06 |
| Abatement Due Date |
2022-12-16 |
| Current Penalty |
11396.0 |
| Initial Penalty |
11396.0 |
| Final Order |
2023-01-10 |
| Nr Instances |
1 |
| Nr Exposed |
3 |
| Related Event Code (REC) |
Complaint |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.37(a)(3): Exit routes were not free and unobstructed: a) On July 13, 2022 and times prior, exits and the exit routes in the A/B and C/D alleyways of the main freezer, were blocked by stacked totes. Note) Certification of corrective action is required for this item. |
|
|
|
343301057
|
1032500
|
2018-07-11
|
903 E. 3000 NORTH, SUGAR CITY, ID, 83448
|
|
| Inspection Type |
Complaint
|
| Scope |
Partial
|
| Safety/Health |
Safety
|
| Close Conference |
2018-07-11
|
| Case Closed |
2018-07-11
|
Related Activity
| Type |
Complaint |
| Activity Nr |
1354873 |
| Safety |
Yes |
|
|
|
343071890
|
1032500
|
2018-04-02
|
903 E. 3000 NORTH, SUGAR CITY, ID, 83448
|
|
| Inspection Type |
FollowUp
|
| Scope |
Partial
|
| Safety/Health |
Safety
|
| Close Conference |
2018-04-03
|
| Emphasis |
N: CHEMNEP
|
| Case Closed |
2020-07-10
|
Related Activity
| Type |
Inspection |
| Activity Nr |
1117009 |
| Safety |
Yes |
|
Violation Items
| Citation ID |
01001 |
| Citaton Type |
Serious |
| Standard Cited |
19100119 C01 |
| Issuance Date |
2018-08-31 |
| Abatement Due Date |
2018-09-27 |
| Current Penalty |
0.0 |
| Initial Penalty |
12934.0 |
| Final Order |
2018-09-27 |
| Nr Instances |
1 |
| Nr Exposed |
7 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.119(c)(1): The employer did not develop a written plan of action regarding the implementation of the employee participation required by this paragraph. (a) Sugar City: On or about April 2, 2018 and at times prior, the potato processing facility uses approximately 14765 lbs. of ammonia to freeze potatoes. Employees have not been involved in the development and implementation of process safety management of the ammonia refrigeration system. Note: Abatement certification and documentation is required for this item. |
|
| Citation ID |
01002 |
| Citaton Type |
Serious |
| Standard Cited |
19100119 D03 I B |
| Issuance Date |
2018-08-31 |
| Abatement Due Date |
2018-09-27 |
| Current Penalty |
6467.0 |
| Initial Penalty |
12934.0 |
| Final Order |
2018-09-27 |
| Nr Instances |
3 |
| Nr Exposed |
7 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.119(d)(3)(i)(B): The employer's piping and instrument diagrams were not accurate and did not represent equipment that was existing and was part of the process. (a) Line B Compressor Room: On or about April 2, 2018 and at times prior, piping and instrument diagrams (P&ID) did not match valves since multiple valves were not labeled. Examples include, but are not limited to no tag on a locked out valve on the high pressure receiver line; condenser drain valve (V1-004) has no tag; and the pressure relief valve (V1-RV1) has a tag with B-5. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01003 |
| Citaton Type |
Serious |
| Standard Cited |
19100119 D03 I F |
| Issuance Date |
2018-08-31 |
| Abatement Due Date |
2018-09-27 |
| Current Penalty |
6467.0 |
| Initial Penalty |
12934.0 |
| Final Order |
2018-09-27 |
| Nr Instances |
1 |
| Nr Exposed |
7 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.119(d)(3)(i)(F): The process safety information did not include information pertaining to the design codes and standards employed. (a) Sugar City: On or about April 2, 2018 and at times prior, the potato processing facility uses approximately 14765 lbs. of ammonia to freeze potatoes. The company could not demonstrate the design codes for ammonia system equipment including but not limited to the construction of the new compressor in Line B, holes in wall of Line B, and ammonia detector. Note: Abatement certification and documentation is required for this item. |
|
| Citation ID |
01004 |
| Citaton Type |
Serious |
| Standard Cited |
19100119 E01 |
| Issuance Date |
2018-08-31 |
| Abatement Due Date |
2018-09-27 |
| Current Penalty |
6467.0 |
| Initial Penalty |
12934.0 |
| Final Order |
2018-09-27 |
| Nr Instances |
1 |
| Nr Exposed |
7 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.119(e)(1): The process hazard analysis did not identify, evaluate, and address the control of the hazards involved in the process: (a) Sugar City: On or about April 2, 2018 and at times prior, the potato processing facility uses approximately 14765 lbs. of ammonia to freeze potatoes. The company has not performed a process hazards analysis for the operation of the ammonia refrigeration system. Note: Abatement certification and documentation is required for this item. |
|
| Citation ID |
01005A |
| Citaton Type |
Serious |
| Standard Cited |
19100119 J02 |
| Issuance Date |
2018-08-31 |
| Abatement Due Date |
2018-09-27 |
| Current Penalty |
6467.0 |
| Initial Penalty |
12934.0 |
| Final Order |
2018-09-27 |
| Nr Instances |
2 |
| Nr Exposed |
7 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.119(j)(2): The employer did not establish written procedures to maintain the on-going integrity of process equipment: (a) Line A Compressor Room: On or about April 2, 2018 and at times prior, the Cool Air Incorporated ammonia monitor does not have a written procedure for calibration. (b) Line B Compressor Room: On or about April 2, 2018 and at times prior, the Calibration Technologies, Inc. ammonia monitor does not have a written procedure for calibration. Note: Abatement documentation and certification is required for this item. |
|
| Citation ID |
01005B |
| Citaton Type |
Serious |
| Standard Cited |
19100119 J04 I |
| Issuance Date |
2018-08-31 |
| Abatement Due Date |
2018-09-27 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2018-09-27 |
| Nr Instances |
2 |
| Nr Exposed |
7 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.119(j)(4)(i): Inspections and tests were not performed on process equipment: (a) Line A Compressor Room: On or about April 2, 2018 and at times prior, the Cool Air Incorporated ammonia monitor was not being calibrated yearly as required by the manufacturer. (b) Line B Compressor Room: On or about April 2, 2018 and at times prior, the Calibration Technologies, Inc. ammonia monitor was not being calibrated every 6 months as required by the manufacturer. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01005C |
| Citaton Type |
Serious |
| Standard Cited |
19100119 J04 III |
| Issuance Date |
2018-08-31 |
| Abatement Due Date |
2018-09-27 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2018-09-27 |
| Nr Instances |
2 |
| Nr Exposed |
7 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.119(j)(4)(iii): The frequency of inspections and tests of process equipment was not consistent with applicable manufacturers' recommendations and good engineering practices, and more frequently if determined to be necessary by prior operating experience. (a) Line A Compressor Room: On or about April 2, 2018 and at times prior, the Cool Air Incorporated ammonia monitor was not being calibrated yearly as required by the manufacturer. (b) Line B Compressor Room: On or about April 2, 2018 and at times prior, the Calibration Technologies, Inc. ammonia monitor was not being calibrated every 6 months as required by the manufacturer. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01006 |
| Citaton Type |
Serious |
| Standard Cited |
19100303 B02 |
| Issuance Date |
2018-08-31 |
| Abatement Due Date |
2018-09-27 |
| Current Penalty |
6467.0 |
| Initial Penalty |
12934.0 |
| Final Order |
2018-09-27 |
| Nr Instances |
1 |
| Nr Exposed |
7 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.303(b)(2): Listed or labeled electrical equipment was not used or installed in accordance with instructions included in the listing or labeling: (a) Line B Compressor Room: On or about April 2, 2018 and at times prior, a Raychem heat tape was plugged into an extension cord which the manufacture requires it to be plugged directly into an outlet. Using an extension cord may not provide protection from electrical related hazards. Note: Abatement certification and documentation is required for this item. |
|
| Citation ID |
02001 |
| Citaton Type |
Serious |
| Standard Cited |
5A0001 |
| Issuance Date |
2018-08-31 |
| Abatement Due Date |
2018-09-27 |
| Current Penalty |
45269.0 |
| Initial Penalty |
64670.0 |
| Final Order |
2018-09-27 |
| Nr Instances |
1 |
| Nr Exposed |
7 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
OSH ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer did not insured that doors of ammonia compressor rooms were tight sealing. (a) Line B Compressor Room: On or about April 2, 2018 and at times prior, the roll-up doors on the south side of the compressor room are not tight sealing. (b) Line A Compressor Room: On or about April 2, 2018 and at times prior, the doors on the south side of the compressor room are not tight sealing. Note: Abatement certification and documentation is required for this item. Dickinson Frozen Food, Inc. was previously cited for this standard or its equivalent standard, which was contained in OSHA inspection #1117009, Cit. 1, Item 3b issued on May 25, 2016, with respect to a workplace located at East 3000 North, Sugar City, Idaho. The final order date was February 28, 2017. |
|
|
|
341359883
|
1032500
|
2016-03-30
|
6198 TREASURE VALLEY WAY, NAMPA, ID, 83687
|
|
| Inspection Type |
Complaint
|
| Scope |
Partial
|
| Safety/Health |
Health
|
| Close Conference |
2016-03-30
|
| Case Closed |
2016-05-24
|
Related Activity
| Type |
Complaint |
| Activity Nr |
1075891 |
| Health |
Yes |
|
Violation Items
| Citation ID |
01001A |
| Citaton Type |
Serious |
| Standard Cited |
19100132 D01 |
| Issuance Date |
2016-04-06 |
| Abatement Due Date |
2016-05-02 |
| Current Penalty |
2200.0 |
| Initial Penalty |
4400.0 |
| Final Order |
2016-04-27 |
| Nr Instances |
1 |
| Nr Exposed |
4 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.132(d)(1): The employer did not assess the workplace to determine if hazards are present, or are likely to be present, which necessitate the use of personal protective equipment (PPE). a) On or about March 21, 2016, or prior thereto, a PPE hazard assessment was not completed for the Steril-Aire UVGI System prior to being incorporated in the warehouse production line. The UVC lamps in the system require that line employees wear eye and face protection. NOTE: Abatement certification is required for this item. |
|
| Citation ID |
01001B |
| Citaton Type |
Serious |
| Standard Cited |
19100133 A01 |
| Issuance Date |
2016-04-06 |
| Abatement Due Date |
2016-05-02 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2016-04-27 |
| Nr Instances |
1 |
| Nr Exposed |
4 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.133(a)(1): The employer did not ensure that each affected employee uses appropriate eye or face protection when exposed to eye or face hazards from flying particles, molten metal, liquid chemicals, acids or caustic liquids, chemical gases or vapors, or potentially injurious light radiation. a) On or about March 21, 2016, or prior thereto, eye and face protection was not used during operation of the Steril-Aire UVGI System in the warehouse production line. The UVC lamps in the system require that line employees wear eye and face protection. NOTE: Abatement was completed for this item. |
|
|
|
341170090
|
1032500
|
2016-01-05
|
903 E. 3000 NORTH, SUGAR CITY, ID, 83448
|
|
| Inspection Type |
Referral
|
| Scope |
Partial
|
| Safety/Health |
Safety
|
| Close Conference |
2016-01-06
|
| Emphasis |
N: CHEMNEP
|
| Case Closed |
2018-09-26
|
Related Activity
| Type |
Referral |
| Activity Nr |
1042529 |
| Safety |
Yes |
|
Violation Items
| Citation ID |
01001 |
| Citaton Type |
Serious |
| Standard Cited |
19100119 C01 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
0.0 |
| Initial Penalty |
7000.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-22 |
| Nr Instances |
1 |
| Nr Exposed |
12 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.119(c)(1): Employers did not develop a written plan of action regarding the implementation of the employee participation required by this paragraph. a) On or about January 5, 2016 and at times prior thereto: Employees were not involved in a process of analyzing the hazards of ammonia and the Process Safety Management of the facility. OR IN THE ALTERNATIVE: OSH ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazard of anhydrous ammonia because the employer had not included employee participation in a process safety management analysis. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01002A |
| Citaton Type |
Serious |
| Standard Cited |
5A0001 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
8500.0 |
| Initial Penalty |
7000.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
12 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
OSH ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not compiled written process safety information for hazards, technology, and equipment. a) On or about January 5, 2016, and at times prior thereto, An analysis of the consequences of deviation was not developed for ammonia releases including but was not limited to the following equipment: heat exchange failure, piping leaks, strainer failure, and potential pressure relief valve failure. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01002B |
| Citaton Type |
Serious |
| Standard Cited |
5A0001 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
2 |
| Nr Exposed |
12 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
OSH ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not compiled written process safety information for hazards, technology, and equipment. a) On or about January 5, 2016, and at times prior thereto, Process & Instrumentation Diagram (P&ID) for Line B: The P&ID for Line B did not include the Kemper Northwest December 3, 2015 modification of the refrigeration line that circumvented the heat exchanger that failed on December 1, 2015. b) On or about January 5, 2016, and at times prior thereto, Process & Instrumentation Diagrams (P&ID) for Line A: The print out of the P&ID for the Line A refrigeration line did not include modifications to the refrigeration pressure vessels. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01002C |
| Citaton Type |
Serious |
| Standard Cited |
5A0001 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
12 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
OSH ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not compiled written process safety information for hazards, technology, and equipment. a) On or about January 5, 2016, and at times prior thereto, Electrical classification of compressor rooms A and B were not maintained. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01002D |
| Citaton Type |
Serious |
| Standard Cited |
5A0001 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
12 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
OSH ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not compiled written process safety information for hazards, technology, and equipment. a) On or about January 5, 2016, and at times prior thereto, process safety information did not address ventilation system design to handle the quantity of ammonia in the refrigeration system. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01002E |
| Citaton Type |
Serious |
| Standard Cited |
19100119 D03 I F |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
12 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.119(d)(3)(i)(F): The process safety information did not include information pertaining to the design codes and standards employed. a) On or about January 5, 2016, and at times prior thereto, process safety information did not include design codes and standards utilized for construction of the B-Line Cloudy Britton Refrigeration System. OR IN THE ALTERNATIVE: OSH ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not compiled written process safety information for hazards, technology, and equipment. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01003A |
| Citaton Type |
Serious |
| Standard Cited |
19100119 D03 II |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
0.0 |
| Initial Penalty |
7000.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
7 |
| Nr Exposed |
12 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.119(d)(3)(ii): The employer did not document that equipment complies with recognized and generally accepted good engineering practices (RAGAGEP). a) Line A Compressor Room, On or about January 5, 2016, and at times prior thereto, the employer did not document that in the Line A Compressor Room, that the structural components of the Line A compressor room were constructed of non-combustible materials. b) Line A Compressor Room, On or about January 5, 2016, and at times prior thereto, the employer did not document that tight fitting doors were installed. c) Line B Compressor Room, On or about January 5, 2016, and at times prior thereto, the employer did not document that the structural components of the Line B compressor room were constructed of non-combustible materials. d) Line B Compressor Room, On or about January 5, 2016, and at times prior thereto, the employer did not document that tight fitting doors were installed. e) Line B Compressor Room, On or about January 5, 2016, and at times prior thereto, the employer did not document that in the Line B Compressor Room, that all electrical equipment in the Line B Compressor Room conformed to requirements for a Class 1 Group D Division 2 location. Two open 110 V Junction boxes and extension cords were observed on January 5, 2016. f) Line B Compressor Room, On or about January 5, 2016, and at times prior thereto, the employer did not document that the ammonia alarm was unplugged. It was not hard wired. g) Line B Refrigeration Line, On or about January 5, 2016, and at times prior thereto, the employer did not document that the room containing the Low Pressure Receiver met protective requirements of a "machinery room." OR IN THE ALTERNATIVE: OSH ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not documented that equipment complies with recognized and generally accepted good engineering practices (RAGAGEP). NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01003B |
| Citaton Type |
Serious |
| Standard Cited |
5A0001 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
8500.0 |
| Initial Penalty |
0.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
7 |
| Nr Exposed |
12 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
OSH ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not documented that equipment complies with recognized and generally accepted good engineering practices (RAGAGEP). a) deleted in formal settlement b) Line A Compressor Room, On or about January 5, 2016, and at times prior thereto, the employer did not document that tight fitting doors were installed. c) deleted in formal settlement d) Line B Compressor Room, On or about January 5, 2016, and at times prior thereto, the employer did not document that tight fitting doors were installed. e) Line B Compressor Room, On or about January 5, 2016, and at times prior thereto, the employer did not document that in the Line B Compressor Room, that all electrical equipment in the Line B Compressor Room conformed to requirements for a Class 1 Group D Division 2 location. Two open 110 V Junction boxes and extension cords were observed on January 5, 2016. f) Line B Compressor Room, On or about January 5, 2016, and at times prior thereto, the employer did not document that the ammonia alarm was unplugged. It was not hard wired. g) Line B Refrigeration Line, On or about January 5, 2016, and at times prior thereto, the employer did not document that the room containing the Low Pressure Receiver met protective requirements of a "machinery room." NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01004 |
| Citaton Type |
Serious |
| Standard Cited |
5A0001 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
0.0 |
| Initial Penalty |
7000.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
225 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
OSHA ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not conducted a process hazard analysis. a) Line A and Line B ammonia refrigeration systems; On or about January 5, 2016, and at times prior thereto: The employer did not perform a process hazard analysis of the Line A and Line B ammonia refrigeration systems. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01005A |
| Citaton Type |
Serious |
| Standard Cited |
5A0001 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
8500.0 |
| Initial Penalty |
7000.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
12 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
OSHA ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not implemented emergency shutdown procedures. a) On or about January 5, 2016, and at times or prior thereto: The employer did not implement written operating procedures for Maintenance employees involved in emergency operations including shutdown procedures addressed in the Dickinson Frozen Foods Ammonia SOP's. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01005B |
| Citaton Type |
Serious |
| Standard Cited |
5A0001 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
12 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
OSHA ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer did not make operating procedures accessible. a) On or about January 5, 2016, and at times or prior thereto: The employer did not make written operating procedures for Maintenance employees involved in ammonia refrigeration activity readily accessible. NOTE: Abatement certification and documentation are required under this item. |
|
| Citation ID |
01006A |
| Citaton Type |
Serious |
| Standard Cited |
5A0001 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
8500.0 |
| Initial Penalty |
7000.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
3 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
OSHA ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not conducted training for employees operating a related process. a) On or about January 5, 2016, and at times or prior thereto: Maintenance employees involved in ammonia refrigeration activity were not trained in the Line A and B ammonia refrigeration system. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01006B |
| Citaton Type |
Serious |
| Standard Cited |
5A0001 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-07-13 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
3 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
OSHA ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not training for employees operating a related process. a) On or about January 5, 2016 and at times prior thereto: Employees did not have adequate knowledge of company refrigeration processes, the written emergency action plan, and of routine responses to ammonia refrigeration system leaks and releases. In addition, the employer did not have documentation of employee training in the Emergency Action Plan, Emergency Respirator Procedures, Ammonia Standard Operating Procedures, and Respirator Training. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01007 |
| Citaton Type |
Serious |
| Standard Cited |
19100119 H02 III |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
0.0 |
| Initial Penalty |
7000.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.119(h)(2)(iii): The employer did not explain to contract employers the applicable provisions of the emergency action plan required by paragraph (n) of this section. a) Line B Compressor Room, On or about December 3, 2015 or at times prior thereto: The employer did not review the company emergency action plan with Kemper Northwest prior to repair work to circumvent the heat exchanger in the Line B compressor room. OR IN THE ALTERNATIVE: OSHA ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not reviewed the emergency action plan with contract employers. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01008 |
| Citaton Type |
Serious |
| Standard Cited |
19100119 I01 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
0.0 |
| Initial Penalty |
7000.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
12 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.119(i)(1): The employer did not perform a pre-startup safety review for new facilities and for modified facilities when the modification is significant enough to require a change in the process safety information. a) Line B Compressor Room; On or about December 3, 2015, The employer did not perform a pre-startup safety review after the Heat Exchanger was circumvented by Kemper Northwest on Line B. OR IN THE ALTERNATIVE: OSHA ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not conducted a pre-startup safety review. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01009A |
| Citaton Type |
Serious |
| Standard Cited |
5A0001 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
8500.0 |
| Initial Penalty |
7000.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
12 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
OSHA ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not implemented written procedures to maintain the on-going integrity of process equipment. a) On or about January 5, 2016, and at times prior thereto: Procedures were not in place to maintain the process equipment on Line A and B including but are not limited to the following equipment: Low Pressure Receivers, High Pressure Receivers, Compressors, Evaporators, Condensers, Pressure Relief Valves, Piping, Controls and Pumps. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01009B |
| Citaton Type |
Serious |
| Standard Cited |
5A0001 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
12 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
OSHA ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not implemented written procedures and training to maintain the on-going integrity of process equipment. a) On or about January 5, 2016, and at times prior thereto: Employees were not trained on maintenance of process equipment on Line A and B including but are not limited to the following equipment on Line A and B refrigeration lines: Low Pressure Receivers, High Pressure Receivers, Compressors, Evaporators, Condensers, Pressure Relief Valves, Piping, Controls and Pumps. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01010 |
| Citaton Type |
Serious |
| Standard Cited |
5A0001 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
8500.0 |
| Initial Penalty |
7000.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
3 |
| Nr Exposed |
12 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
OSHA ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not implemented written procedures to maintain the on-going integrity of process equipment. a) On or about January 27, 2016, and at times prior thereto: High Pressure Receiver Line A - pressure relief valve had an expiration date of 2014. b) On or about January 27, 2016, and at times prior thereto: Low Pressure Receiver Line A - pressure relief valve had an expiration date of 2014. c) On or about January 27, 2016, and at times prior thereto: Low Pressure Receiver Line A - pressure relief valve had an illegible tag. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01011 |
| Citaton Type |
Serious |
| Standard Cited |
5A0001 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-07-13 |
| Current Penalty |
8500.0 |
| Initial Penalty |
7000.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
4 |
| Nr Exposed |
1 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
OSHA ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not implemented procedures to maintain the on-going integrity of process equipment. a) Compressor Rooms A and B; On or about December 4, 2015 and at times prior thereto, employees were exposed to the hazard of using a Goodall N2000 Anhydrous Ammonia hose beyond its service life. The hose had an end of service life date of 2009. The hose was used to transfer anhydrous ammonia from a nurse tank in Compressor Room A to the High Pressure Receiver in Compressor Room B. From 2003 to 2015, the hose had periodically been utilized to transfer anhydrous ammonia from the High Pressure Receiver in Compressor Room B, to the High Pressure Receiver on Line A. This operation was conducted to prevent line shutdowns of the ammonia refrigeration system. b) On or about January 27, 2016, and at times prior thereto: High Pressure Receiver Line A - pressure relief valve had an expiration date of 2014. c) On or about January 27, 2016, and at times prior thereto: Low Pressure Receiver Line A - pressure relief valve had an expiration date of 2014. d) On or about January 27, 2016, and at times prior thereto: Low Pressure Receiver Line A - pressure relief valve had an illegible tag. NOTE: Abatement certification and documentation is required for this item. |
|
| Citation ID |
01012 |
| Citaton Type |
Serious |
| Standard Cited |
5A0001 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
8500.0 |
| Initial Penalty |
7000.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
OSHA ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer did not issue permits and procedures for hot work operations. a) Line B Compressor Room; On or about December 3, 2015, and at times prior thereto: The employer did not issue a hot work permit for hot work operations conducted on the Line B Heat Exchanger that was circumvented by Kemper Northwest. NOTE: Abatement certification and documentation are required under this item. |
|
| Citation ID |
01013A |
| Citaton Type |
Serious |
| Standard Cited |
19100119 L01 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
0.0 |
| Initial Penalty |
7000.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.119(l)(1): The employer did not establish and implement written procedures to manage changes (except for "replacements in kind") to process chemicals, technology, equipment, and procedures; and, changes to facilities that affect a covered process. a) Line B Compressor Room, On or about December 3, 2015, and at times prior thereto: The employer did not implement management of change procedures for the modification and circumvention of the Line B Heat Exchanger by Kemper Northwest. OR IN THE ALTERNATIVE: OSHA ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not implemented written procedures to manage changes to process chemicals, technology, equipment, procedures and facilities that affect a covered process. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01013B |
| Citaton Type |
Serious |
| Standard Cited |
19100119 L03 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
12 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.119(l)(3): Employees involved in operating a process and maintenance and contract employees whose job tasks will be affected by a change in the process were not informed of, and trained in, the change prior to start-up of the process or affected part of the process. a) Line B Compressor Room: On or about December 3, 2015, and at times prior thereto: The employer did not inform employees of the change, nor train employees affected by modification and circumvention of the Line B Heat Exchanger by Kemper Northwest. OR IN THE ALTERNATIVE: OSHA ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not implemented written procedures and related training to manage changes to process chemicals, technology, equipment, procedures and facilities that affect a covered process. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01014A |
| Citaton Type |
Serious |
| Standard Cited |
5A0001 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
8500.0 |
| Initial Penalty |
7000.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
12 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
OSHA ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not established an incident investigation team with at least one person knowledgeable in the process involved, including a contract employee if the incident involved work of the contractor, and other persons with appropriate knowledge and experience to thoroughly investigate and analyze the incident. a) Line B Compressor Room: On or about December 1, 2015, and at times prior thereto: An ammonia release incident related to the release of ammonia from the Heat Exchanger in the Line B Compressor Room led to potential IDLH (Immediately Dangerous to Life and Health) conditions in an employer led emergency response. After the incident, the investigation team of Dickinson Frozen Foods did not include the ammonia systems expert of the company, nor their ammonia refrigeration contractor, Kemper Northwest. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01014B |
| Citaton Type |
Serious |
| Standard Cited |
5A0001 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
12 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
OSHA ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not established a system to promptly address and resolve the incident report findings and recommendations. a) Line B Compressor Room: On or about December 1, 2015, and at times prior thereto: An ammonia release incident related to the release of ammonia from the Heat Exchanger in the Line B Compressor Room led to potential IDLH (Immediately Dangerous to Life and Health) conditions in an employer led emergency response. The employer did not establish a system or methodology to address the cause of the release and prevent future occurrences. NOTE: Abatement certification and documentation are required for this item. |
|
| Citation ID |
01015 |
| Citaton Type |
Serious |
| Standard Cited |
5A0001 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-10-06 |
| Current Penalty |
8500.0 |
| Initial Penalty |
7000.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
OSHA ACT of 1970 Section (5)(a)(1): The employer did not furnish employment and a place of employment which were free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to the hazards of anhydrous ammonia because the employer had not implemented an emergency action plan. a) On or about December 1, 2015, and at times prior thereto, the employer's emergency plan was not adequately implemented in that maintenance employees had not been fully trained prior to responding to an ammonia release and were exposed to unknown concentrations. NOTE: Abatement certification and documentation are required for this item. |
|
|
|
341243723
|
1032500
|
2016-01-05
|
903 E. 3000 NORTH, SUGAR CITY, ID, 83448
|
|
| Inspection Type |
Referral
|
| Scope |
Partial
|
| Safety/Health |
Health
|
| Close Conference |
2016-01-05
|
| Case Closed |
2017-04-28
|
Related Activity
| Type |
Referral |
| Activity Nr |
1042529 |
| Safety |
Yes |
|
Violation Items
| Citation ID |
01001A |
| Citaton Type |
Serious |
| Standard Cited |
19100038 F01 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-07-13 |
| Current Penalty |
5000.0 |
| Initial Penalty |
7000.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.38(f)(1): The employer did not review the emergency action plan with each employee covered by the plan when the employee was assigned initially to a job: a) On or about December 1, 2015, in the workplace: The employer did not review employee responsibilities under Section 15.1 of the emergency action plan with Maintenance employees with regards to ammonia releases. Abatement certification and documentation are required under this item. |
|
| Citation ID |
01001B |
| Citaton Type |
Serious |
| Standard Cited |
19100038 F02 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-07-13 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.38(f)(2): The employer did not review the emergency action plan with each employee covered by the plan when the employee's responsibilities under the plan change. a) On or about December 1, 2015, in the workplace: The employer did not review employee responsibilities during an ammonia release under Section 15.1 of the emergency action plan with employees that have been re-assigned to the maintenance department. Abatement certification and documentation are required under this item. |
|
| Citation ID |
01002 |
| Citaton Type |
Serious |
| Standard Cited |
19100120 Q01 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-06-21 |
| Current Penalty |
5000.0 |
| Initial Penalty |
7000.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
6 |
| Nr Exposed |
578 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.120(q)(1): The employer did not implement an emergency response plan to handle anticipated emergencies prior to commencement of emergency response operations: a) On or about December 1, 2015, or prior thereto: the facility did not implement pre-emergency planning and coordination with outside parties during anhydrous ammonia releases. b) On or about December 1, 2015, or prior thereto: the facility did not implement training and communication procedures during anhydrous ammonia releases. c) On or about December 1, 2015, or prior thereto: the facility did not implement emergency recognition and prevention procedures for anhydrous ammonia releases. d) On or about December 1, 2015, or prior thereto: the facility did not implement decontamination procedures during anhydrous ammonia releases. e) On or about December 1, 2015, or prior thereto: the facility did not implement critique of response and follow-up after anhydrous ammonia releases. f) On or about December 1, 2015, or prior thereto: the facility did not implement PPE and emergency equipment procedures during anhydrous ammonia releases. Abatement documentation and certification required for this item. |
|
| Citation ID |
01003 |
| Citaton Type |
Serious |
| Standard Cited |
19100120 Q10 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-07-13 |
| Current Penalty |
5000.0 |
| Initial Penalty |
7000.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
3 |
| Nr Exposed |
2 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.120(q)(10): Chemical protective clothing and equipment to be used by organized and designated HAZMAT team members, or to be used by hazardous materials specialists, did not meet the requirements of paragraphs (g)(3) through (5) of this section. a) On or about December 1, 2015, or prior thereto: The employer did not provide appropriate chemical protective gloves ammonia releases. Maintenance Tech 1 and Generalists were required to participate in ammonia related emergency responses and had not received appropriate PPE. b) On or about December 1, 2015, or prior thereto: The employer did not provide appropriate chemical protective boots ammonia releases. Maintenance Tech 1 and Generalists were required to participate in ammonia related emergency responses and had not received appropriate PPE. c) On or about December 1, 2015, or prior thereto: The employer did not provide appropriate chemical protective coveralls ammonia releases. Maintenance Tech 1 and Generalists were required to participate in ammonia related emergency responses and had not received appropriate PPE. Abatement certification and documentation are required under this item. |
|
| Citation ID |
01004A |
| Citaton Type |
Serious |
| Standard Cited |
19100134 E01 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-07-13 |
| Current Penalty |
0.0 |
| Initial Penalty |
7000.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.134(e)(1): The employer did not provide a medical evaluation to determine the employee's ability to use a respirator, before the employee is fit tested or required to use the respirator in the workplace. a) On or about December 1, 2015, or prior thereto: Maintenance employees responded to ammonia releases with full face cartridge respirators, but were not medically evaluated. Ammonia releases have included the release from the Line B refrigeration system. Abatement certification and documentation are required under this item. |
|
| Citation ID |
01004B |
| Citaton Type |
Serious |
| Standard Cited |
19100134 F02 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-07-13 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.134(f)(2): The employer did not ensure that an employee using a tight-fitting facepiece respirator is fit tested prior to initial use of the respirator, whenever a different respirator facepiece (size, style, model or make) is used, and at least annually thereafter. a) On or about December 1, 2015, or prior thereto: Employees required to wear full face respirators for responding to ammonia releases were not fit tested. Emergency responses have included the release of ammonia from the Line B refrigeration system. Abatement certification and documentation are required under this item. |
|
| Citation ID |
02001A |
| Citaton Type |
Serious |
| Standard Cited |
19100120 Q06 |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-07-13 |
| Current Penalty |
70000.0 |
| Initial Penalty |
70000.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
3 |
| Nr Exposed |
4 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.120(q)(6): Training was not based on the duties and function to be performed by each responder of an emergency response organization. The skill and knowledge levels required for all new responders, those hired after the effective date of this standard, was not conveyed to them through training before they are permitted to take part in actual emergency operations on an incident. a) On or about December 1, 2015, or prior thereto: Maintenance employees responded to an ammonia release in the role of a Hazardous Materials Technician without proper emergency response training per 1910.120(q)(6)(iii). The response to ammonia releases are required by Dickinson Frozen Foods, Inc. b) On or about December 1, 2015, or prior thereto: Maintenance employees responded to an ammonia release in the role of an Hazardous Materials Specialist without proper emergency response training per 1910.120(q)(6)(iv). The response to ammonia releases are required by Dickinson Frozen Foods, Inc. c) On or about December 1, 2015, or prior thereto: Maintenance employees responded to an ammonia release in the role of an Incident Commander without proper emergency response training per 1910.120(q)(6)(v). The response to ammonia releases are required by Dickinson Frozen Foods, Inc. Abatement certification and documentation are required under this item. |
|
| Citation ID |
02001B |
| Citaton Type |
Serious |
| Standard Cited |
19100120 Q03 II |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-07-13 |
| Current Penalty |
0.0 |
| Initial Penalty |
70000.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
4 |
| Nr Exposed |
4 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.120(q)(3)(ii): The individual in charge of the incident command system did not identify, to the extent possible, all hazardous substances or conditions present and did not address, as appropriate, site analysis, use of engineering controls, maximum exposure limits, hazardous substance handling procedures and the use of any new technologies: a) On or about December 1, 2015, or prior thereto, in the Line B Compressor Room: The Tech 2 was exposed to unknown levels of ammonia while wearing a full face cartridge respirator when responding to an ammonia leak. Ammonia level measurements were not taken by employees during the response. b) On or about December 1, 2015, or prior thereto, in the Line B Compressor Room: The Tech 1 was exposed to unknown levels of ammonia while wearing a full face cartridge respirator when responding to an ammonia leak. Ammonia level measurements were not taken by employees during the response. c) On or about December 1, 2015, or prior thereto, in the Line B Compressor Room: The Generalist was exposed to unknown levels of ammonia while wearing a full face cartridge respirator when responding to an ammonia leak. Ammonia level measurements were not taken by employees during the response. d) On or about December 1, 2015, or prior thereto, in the Line B Compressor Room: The Maintenance Manager was exposed to unknown levels of ammonia while wearing a full face cartridge respirator when responding to an ammonia leak. Ammonia level measurements were not taken by employees during the response. Abatement certification and documentation are required under this item. |
|
| Citation ID |
02001C |
| Citaton Type |
Serious |
| Standard Cited |
19100120 Q03 IV |
| Issuance Date |
2016-05-25 |
| Abatement Due Date |
2016-07-13 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Contest Date |
2016-06-21 |
| Final Order |
2017-04-24 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| Related Event Code (REC) |
Referral |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.120(q)(3)(iv): Employees engaged in emergency response and exposed to hazardous substances presenting an inhalation hazard or potential inhalation hazard did not wear positive pressure self-contained breathing apparatus while engaged in emergency response, until such time that the individual in charge of the ICS determined through the use of air monitoring that a decreased level of respiratory protection did not result in hazardous exposures to employees: a) On or about December 1, 2015, or prior thereto, in the Line B Compressor Room: The Tech 2 was exposed to unknown levels of ammonia while wearing a full face cartridge respirator when responding to an ammonia leak. Ammonia level measurements were not taken by employees during the response. b) On or about December 1, 2015, or prior thereto, in the Line B Compressor Room: The Tech 1 was exposed to unknown levels of ammonia while wearing a full face cartridge respirator when responding to an ammonia leak. Ammonia level measurements were not taken by employees during the response. c) On or about December 1, 2015, or prior thereto, in the Line B Compressor Room: The Generalist was exposed to unknown levels of ammonia while wearing a full face cartridge respirator when responding to an ammonia leak. Ammonia level measurements were not taken by employees during the response. d) On or about December 1, 2015, or prior thereto, in the Line B Compressor Room: The Maintenance Manager was exposed to unknown levels of ammonia while wearing a full face cartridge respirator when responding to an ammonia leak. Ammonia level measurements were not taken by employees during the response. Abatement certification and documentation are required under this item. |
|
|
|
341024792
|
1032500
|
2015-10-28
|
600 NW 21ST STREET, FRUITLAND, ID, 83619
|
|
| Inspection Type |
Complaint
|
| Scope |
Partial
|
| Safety/Health |
Safety
|
| Close Conference |
2015-10-29
|
| Emphasis |
L: FORKLIFT
|
| Case Closed |
2016-06-17
|
Related Activity
| Type |
Complaint |
| Activity Nr |
1033132 |
| Safety |
Yes |
|
Violation Items
| Citation ID |
01001A |
| Citaton Type |
Serious |
| Standard Cited |
19100037 A02 |
| Issuance Date |
2016-02-16 |
| Abatement Due Date |
2016-05-01 |
| Current Penalty |
4200.0 |
| Initial Penalty |
7000.0 |
| Final Order |
2016-03-07 |
| Nr Instances |
1 |
| Nr Exposed |
18 |
| Related Event Code (REC) |
Complaint |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.37(a)(2): Exit routes were not arranged so that employees did not have to travel toward a high hazard area: a) Blue Room: On or about October 21, 2015 and at times prior to; the exterior exit door was welded shut and the nearest exit was through ammonia compressor room A and then through ammonia compressor room B before exiting the building. Note) Abatement certification and documentation ARE required for this item. |
|
| Citation ID |
01001B |
| Citaton Type |
Serious |
| Standard Cited |
19100037 A03 |
| Issuance Date |
2016-02-16 |
| Abatement Due Date |
2016-05-01 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2016-03-07 |
| Nr Instances |
1 |
| Nr Exposed |
22 |
| Related Event Code (REC) |
Complaint |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.37(a)(3): Exit routes were not free and unobstructed. Materials or equipment were placed, either permanently or temporarily, within the exit route: a) Blue Room: On or about October 21, 2015 and at times prior to; employees accessing the room to perform work did not have a free and unobstructed path to an emergency exit or internal exit. Fixed mechanical equipment to include belts and railings limit aisle clearance. Note) Abatement certification and documentation ARE required for this item. |
|
| Citation ID |
01001C |
| Citaton Type |
Serious |
| Standard Cited |
19100037 B05 |
| Issuance Date |
2016-02-16 |
| Abatement Due Date |
2016-04-01 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2016-03-07 |
| Nr Instances |
1 |
| Nr Exposed |
369 |
| Related Event Code (REC) |
Complaint |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.37(b)(5): Each doorway or passage along an exit access that could be mistaken for an exit was not marked "Not an Exit" or similar designation, or be identified by a sign indicating its actual use (e.g. closet): a) Blue Room: On or about October 21, 2015, and at times prior to, an exit door to the outside was welded shut, but was not labeled as "Not an Exit" to warn employees that the door was not operational. Note) Abatement certification and documentation ARE required for this item. |
|
| Citation ID |
01002A |
| Citaton Type |
Serious |
| Standard Cited |
19100146 D04 VIII |
| Issuance Date |
2016-02-16 |
| Abatement Due Date |
2016-04-01 |
| Current Penalty |
3600.0 |
| Initial Penalty |
7000.0 |
| Final Order |
2016-03-07 |
| Nr Instances |
2 |
| Nr Exposed |
8 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.146(d)(4)(viii): Under the permit-required confined space program required by 29 CFR 1910.146(c)(4), the employer did not provide rescue and emergency equipment needed to comply with 29 CFR 1910.146(d)(9). a) Wastewater manholes: On or about October 28, 2015 and at times prior to; maintenance technicians entered a permit-required confined space and rescue equipment was not positioned or available for use in the event a rescue operation was necessary. Rescue equipment may include, but is not limited to, tripod and mechanical winch designed for emergency rescue operations. Note) Abatement certification and documentation ARE required for this item. |
|
| Citation ID |
01002B |
| Citaton Type |
Serious |
| Standard Cited |
19100146 K01 II |
| Issuance Date |
2016-02-16 |
| Abatement Due Date |
2016-04-01 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2016-03-07 |
| Nr Instances |
1 |
| Nr Exposed |
8 |
| Related Event Code (REC) |
Complaint |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.146(k)(1)(ii): The employer did not ensure that each member of the rescue service was trained to perform the assigned rescue duties: a) Wastewater manholes vicinity: On or about October 28, 2015, the employer had not evaluated the local fire department's ability to provide rescue services. Note) Abatement certification and documentation ARE required for this item. |
|
| Citation ID |
01002C |
| Citaton Type |
Serious |
| Standard Cited |
19100146 K02 II |
| Issuance Date |
2016-02-16 |
| Abatement Due Date |
2016-04-01 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2016-03-07 |
| Nr Instances |
1 |
| Nr Exposed |
8 |
| Related Event Code (REC) |
Complaint |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.146(k)(2)(ii): Affected employees were not trained to perform assigned rescue duties. The employer did not ensure that such employees had successfully completed the training required to establish proficiency as an authorized entrant, as provided by paragraphs (g) and (h) of this section: a) On or about October 21, 2015 and at times prior to, maintenance technicians who were required to enter wastewater manhole(s) to repair equipment (e.g.; pumps) had not participated in confined space rescue operations training. Note) Abatement certification and documentation ARE required for this item. |
|
| Citation ID |
01003A |
| Citaton Type |
Serious |
| Standard Cited |
19100146 D03 |
| Issuance Date |
2016-02-16 |
| Abatement Due Date |
2016-04-01 |
| Current Penalty |
3600.0 |
| Initial Penalty |
7000.0 |
| Final Order |
2016-03-07 |
| Nr Instances |
1 |
| Nr Exposed |
8 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.146(d)(3): Under the permit-required confined space program required by 29 CFR 1910.146(c)(4), the employer did not develop and implement the means, procedures, and practices necessary for safe permit space entry operations, including, but not limited to items (d)(3)(i) through (d)(3)(vi) of this paragraph. a) Wastewater manholes: On or about October 28, 2015 and at times prior thereto, maintenance technicians entered a manhole without the availability of employer required rescue equipment in the event a rescue operation was necessary. Rescue equipment may include but is not limited to a tripod and winch designed for emergency rescue. b) Wastewater manholes: On or about October 28, 2015 and at times prior thereto, maintenance technicians entered a manhole without completing an entry permit for a permit required confined space. c) Wastewater manholes: On or about October 28, 2015 and at times prior thereto, maintenance technicians entered a manhole without having completed a rescue exercise with local emergency services. Note) Abatement certification and documentation ARE required for tjhis item. |
|
| Citation ID |
01003B |
| Citaton Type |
Serious |
| Standard Cited |
19100146 D13 |
| Issuance Date |
2016-02-16 |
| Abatement Due Date |
2016-04-01 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2016-03-07 |
| Nr Instances |
1 |
| Nr Exposed |
8 |
| Related Event Code (REC) |
Complaint |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.146(d)(13): Entry operations were not reviewed when the employer had reason to believe that the measures taken under the permit space program would not protect employees and revise the program to correct deficiencies found to exist before subsequent entries were authorized. a) Wastewater manholes: On or about October 28, 2015 and at times prior thereto, maintenance technicians entered a manhole without the availability of employer required rescue equipment in the event a rescue operation was necessary. Rescue equipment may include but is not limited to a tripod and winch designed for emergency rescue. b) Wastewater manholes: On or about October 28, 2015 and at times prior thereto, maintenance technicians entered a manhole without completing an entry permit for a permit required confined space. c) Wastewater manholes: On or about October 28, 2015 and at times prior thereto, maintenance technicians entered a manhole without having completed a rescue exercise with local emergency services. Note) Abatement documentation and certification ARE required for this item. |
|
| Citation ID |
01004A |
| Citaton Type |
Serious |
| Standard Cited |
19100146 E01 |
| Issuance Date |
2016-02-16 |
| Abatement Due Date |
2016-04-01 |
| Current Penalty |
3600.0 |
| Initial Penalty |
7000.0 |
| Final Order |
2016-03-07 |
| Nr Instances |
1 |
| Nr Exposed |
8 |
| Related Event Code (REC) |
Complaint |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.146(e)(1): Before entry into a permit space was authorized, the employer did not document the completion of measures required by 29 CFR 1910.146(d)(3) by preparing an entry permit. a) On or about October 28, 2015 and at times prior to; permit required confined space permits were not completed prior to maintenance employees being directed to enter wastewater manholes. Note) Abatement certification and documentation ARE required for this item. |
|
| Citation ID |
01004B |
| Citaton Type |
Serious |
| Standard Cited |
19100146 E03 |
| Issuance Date |
2016-02-16 |
| Abatement Due Date |
2016-04-01 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2016-03-07 |
| Nr Instances |
1 |
| Nr Exposed |
8 |
| Related Event Code (REC) |
Complaint |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.146(e)(3): A completed permit was not made available at the time of entry to all authorized entrants or their authorized representatives, by posting it at the entry portal or by any other equally effective means, so that the entrants could confirm that pre-entry preparations have been completed: a) On or about October 28, 2015 and at times prior to; the employer did not designate an entry supervisor to initiate/review permits and assure that permits were completed prior to maintenance employees being directed to enter wastewater manholes. Note ) Abatement certification and documentation ARE required for this item. |
|
| Citation ID |
01004C |
| Citaton Type |
Serious |
| Standard Cited |
19100146 E06 |
| Issuance Date |
2016-02-16 |
| Abatement Due Date |
2016-04-01 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2016-03-07 |
| Nr Instances |
6 |
| Nr Exposed |
8 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.146(e)(6): The employer did not retain each canceled entry permit for at least 1 year to facilitate the review of the permit-required confined space (PRCS) program required by paragraph (d)(14) of this section: a) On or about October 28, 2015, and at times prior to; the employer did not document entry procedures for the past six months and did not retain cancelled entry permits for the past year where maintenance employees were directed to enter wastewater manholes. Employer PRCS program review on 5/11/2015 did not document program deficiencies. Note) Abatement certification and documentation ARE required for this item. |
|
|
|
339556128
|
1032500
|
2014-01-13
|
600 NORTHWEST 21ST STREET, FRUITLAND, ID, 83619
|
|
| Inspection Type |
Complaint
|
| Scope |
Partial
|
| Safety/Health |
Safety
|
| Close Conference |
2014-01-13
|
| Case Closed |
2014-06-16
|
Related Activity
| Type |
Complaint |
| Activity Nr |
867753 |
| Safety |
Yes |
|
Violation Items
| Citation ID |
01001 |
| Citaton Type |
Serious |
| Standard Cited |
19100023 C01 |
| Issuance Date |
2014-04-02 |
| Current Penalty |
4000.0 |
| Initial Penalty |
5000.0 |
| Final Order |
2014-04-30 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
1 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.23(c)(1): Every open-sided floor or platform 4 feet or more above adjacent floor or ground level was not guarded by a standard railing (or the equivalent as specified in paragraph (e)(3) of this section) on all open sides except where there is entrance to a ramp, stairway, or fixed ladder. a) On or about January 13, 2014, Motor Defrosting Area - A platform 74 inches high was not guarded by a standard railing on an open side. Abatement was completed for this item. Dickinson Frozen Foods was previously cited for a violation of this occupational safety and health standard or its equivalent standard, which was contained in OSHA inspection number 311577985, citation number 1, item number 1, and was affirmed as a final order on September 1, 2009 with respect to a workplace located at 600 Northwest 21st Street, in Fruitland, Idaho 83619. |
|
|
|
311577985
|
1032500
|
2009-05-11
|
600 NORTHWEST 21ST STREET, FRUITLAND, ID, 83619
|
|
| Inspection Type |
Planned
|
| Scope |
Complete
|
| Safety/Health |
Safety
|
| Close Conference |
2009-05-13
|
| Emphasis |
N: SSTARG08
|
| Case Closed |
2010-06-29
|
Violation Items
| Citation ID |
01001 |
| Citaton Type |
Serious |
| Standard Cited |
19100023 C01 |
| Issuance Date |
2009-08-07 |
| Abatement Due Date |
2009-08-19 |
| Current Penalty |
2275.0 |
| Initial Penalty |
4500.0 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
10 |
|
| Citation ID |
01002A |
| Citaton Type |
Serious |
| Standard Cited |
19100146 C03 |
| Issuance Date |
2009-08-07 |
| Abatement Due Date |
2009-09-02 |
| Current Penalty |
925.0 |
| Initial Penalty |
1800.0 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
02 |
|
| Citation ID |
01002B |
| Citaton Type |
Serious |
| Standard Cited |
19100147 C04 II |
| Issuance Date |
2009-08-07 |
| Abatement Due Date |
2009-09-02 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
02 |
|
| Citation ID |
01003 |
| Citaton Type |
Serious |
| Standard Cited |
19100219 F03 |
| Issuance Date |
2009-08-07 |
| Abatement Due Date |
2009-09-02 |
| Current Penalty |
1150.0 |
| Initial Penalty |
2250.0 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
03 |
|
| Citation ID |
01004 |
| Citaton Type |
Serious |
| Standard Cited |
19100307 C02 I |
| Issuance Date |
2009-08-07 |
| Abatement Due Date |
2010-03-31 |
| Current Penalty |
1125.0 |
| Initial Penalty |
2250.0 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
03 |
|
| Citation ID |
01005 |
| Citaton Type |
Serious |
| Standard Cited |
19100334 C02 |
| Issuance Date |
2009-08-07 |
| Abatement Due Date |
2009-08-12 |
| Current Penalty |
675.0 |
| Initial Penalty |
1350.0 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
01 |
|
|
|
311582985
|
1032500
|
2009-05-11
|
600 NORTHWEST 21ST STREET, FRUITLAND, ID, 83619
|
|
| Inspection Type |
Planned
|
| Scope |
Complete
|
| Safety/Health |
Health
|
| Close Conference |
2009-05-13
|
| Emphasis |
N: SSTARG08
|
| Case Closed |
2009-11-09
|
Related Activity
| Type |
Inspection |
| Activity Nr |
311577985 |
|
Violation Items
| Citation ID |
01001A |
| Citaton Type |
Serious |
| Standard Cited |
19100120 Q02 |
| Issuance Date |
2009-08-07 |
| Abatement Due Date |
2009-11-02 |
| Current Penalty |
2250.0 |
| Initial Penalty |
4500.0 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
10 |
|
| Citation ID |
01001B |
| Citaton Type |
Serious |
| Standard Cited |
19100120 Q06 IC |
| Issuance Date |
2009-08-07 |
| Abatement Due Date |
2009-10-02 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
10 |
|
| Citation ID |
01001C |
| Citaton Type |
Serious |
| Standard Cited |
19100134 D01 III |
| Issuance Date |
2009-08-07 |
| Abatement Due Date |
2009-10-02 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
10 |
|
| Citation ID |
01002A |
| Citaton Type |
Serious |
| Standard Cited |
19100134 C01 VII |
| Issuance Date |
2009-08-07 |
| Abatement Due Date |
2009-09-02 |
| Current Penalty |
900.0 |
| Initial Penalty |
1800.0 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
02 |
|
| Citation ID |
01002B |
| Citaton Type |
Serious |
| Standard Cited |
19100134 E01 |
| Issuance Date |
2009-08-07 |
| Abatement Due Date |
2009-09-02 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
02 |
|
| Citation ID |
01002C |
| Citaton Type |
Serious |
| Standard Cited |
19100134 F01 |
| Issuance Date |
2009-08-07 |
| Abatement Due Date |
2009-09-02 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
02 |
|
| Citation ID |
01003 |
| Citaton Type |
Other |
| Standard Cited |
19101200 F05 I |
| Issuance Date |
2009-08-07 |
| Abatement Due Date |
2009-11-01 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
01 |
|
|
|
308340975
|
1032500
|
2005-08-15
|
600 NORTHWEST 21ST STREET, FRUITLAND, ID, 83619
|
|
| Inspection Type |
Referral |
| Scope |
Partial |
| Safety/Health |
Health |
| Close Conference |
2005-08-15 |
| Case Closed |
2006-01-12 |
Related Activity
| Type |
Referral |
| Activity Nr |
200242139 |
| Health |
Yes |
|
Violation Items
| Citation ID |
01001 |
| Citaton Type |
Serious |
| Standard Cited |
19100023 C01 |
| Issuance Date |
2005-10-26 |
| Abatement Due Date |
2005-11-28 |
| Current Penalty |
1700.0 |
| Initial Penalty |
3150.0 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Related Event Code (REC) |
Referral |
| Gravity |
05 |
|
| Citation ID |
01002 |
| Citaton Type |
Other |
| Standard Cited |
19100036 G02 |
| Issuance Date |
2005-10-26 |
| Abatement Due Date |
2005-11-28 |
| Initial Penalty |
1500.0 |
| Nr Instances |
1 |
| Nr Exposed |
4 |
| Related Event Code (REC) |
Referral |
| Gravity |
02 |
|
| Citation ID |
02001A |
| Citaton Type |
Other |
| Standard Cited |
19100095 C01 |
| Issuance Date |
2005-10-26 |
| Abatement Due Date |
2005-11-28 |
| Nr Instances |
3 |
| Nr Exposed |
3 |
| Related Event Code (REC) |
Referral |
| Gravity |
01 |
|
| Citation ID |
02001B |
| Citaton Type |
Other |
| Standard Cited |
19100095 D01 |
| Issuance Date |
2005-10-26 |
| Abatement Due Date |
2005-12-20 |
| Nr Instances |
3 |
| Nr Exposed |
10 |
| Related Event Code (REC) |
Referral |
| Gravity |
01 |
|
|
|
17732652
|
1032500
|
1988-08-11
|
600 NORTHWEST 21ST STREET, FRUITLAND, ID, 83619
|
|
| Inspection Type |
FollowUp |
| Scope |
Partial |
| Safety/Health |
Health |
| Close Conference |
1988-08-11 |
| Case Closed |
1990-11-07 |
Related Activity
| Type |
Inspection |
| Activity Nr |
103191995 |
|
Violation Items
| Citation ID |
01001A |
| Citaton Type |
Serious |
| Standard Cited |
19100134 D03 |
| Issuance Date |
1988-09-28 |
| Abatement Due Date |
1988-10-17 |
| Current Penalty |
450.0 |
| Initial Penalty |
450.0 |
| Nr Instances |
2 |
| Nr Exposed |
6 |
| Gravity |
05 |
|
| Citation ID |
01001B |
| Citaton Type |
Other |
| Standard Cited |
19100134 E03 I |
| Issuance Date |
1988-09-28 |
| Abatement Due Date |
1988-10-31 |
| Nr Instances |
1 |
| Nr Exposed |
6 |
| Gravity |
05 |
|
| Citation ID |
01001C |
| Citaton Type |
Serious |
| Standard Cited |
19100134 E04 |
| Issuance Date |
1988-09-28 |
| Abatement Due Date |
1988-10-17 |
| Nr Instances |
1 |
| Nr Exposed |
6 |
| Gravity |
05 |
|
| Citation ID |
01001D |
| Citaton Type |
Serious |
| Standard Cited |
19100134 E05 |
| Issuance Date |
1988-09-28 |
| Abatement Due Date |
1988-10-17 |
| Nr Instances |
1 |
| Nr Exposed |
6 |
| Gravity |
05 |
|
| Citation ID |
02001A |
| Citaton Type |
Repeat |
| Standard Cited |
19100134 F01 |
| Issuance Date |
1988-09-28 |
| Abatement Due Date |
1988-10-17 |
| Current Penalty |
900.0 |
| Initial Penalty |
900.0 |
| Nr Instances |
2 |
| Nr Exposed |
6 |
| Gravity |
05 |
|
| Citation ID |
02001B |
| Citaton Type |
Repeat |
| Standard Cited |
19100134 F02 I |
| Issuance Date |
1988-09-28 |
| Abatement Due Date |
1988-10-31 |
| Nr Instances |
2 |
| Nr Exposed |
6 |
| Gravity |
05 |
|
| Citation ID |
02002 |
| Citaton Type |
Repeat |
| Standard Cited |
19101200 F04 I |
| Issuance Date |
1988-09-28 |
| Abatement Due Date |
1988-10-24 |
| Current Penalty |
180.0 |
| Initial Penalty |
180.0 |
| Nr Instances |
1 |
| Nr Exposed |
4 |
| Gravity |
01 |
|
| Citation ID |
03001 |
| Citaton Type |
Other |
| Standard Cited |
19100095 L01 |
| Issuance Date |
1988-09-28 |
| Abatement Due Date |
1988-10-24 |
| Nr Instances |
1 |
| Nr Exposed |
85 |
| Gravity |
06 |
|
| Citation ID |
03002 |
| Citaton Type |
Other |
| Standard Cited |
19100134 B05 |
| Issuance Date |
1988-09-28 |
| Abatement Due Date |
1988-10-07 |
| Nr Instances |
2 |
| Nr Exposed |
6 |
| Gravity |
06 |
|
| Citation ID |
03003 |
| Citaton Type |
Other |
| Standard Cited |
19101200 F04 II |
| Issuance Date |
1988-09-28 |
| Abatement Due Date |
1988-10-17 |
| Nr Instances |
1 |
| Nr Exposed |
85 |
| Gravity |
01 |
|
|
|
101895464
|
1032500
|
1987-10-06
|
600 NORTHWEST 21ST STREET, FRUITLAND, ID, 83619
|
|
| Inspection Type |
Monitoring |
| Scope |
Partial |
| Safety/Health |
Health |
| Close Conference |
1987-10-06 |
| Case Closed |
1988-04-25 |
Related Activity
| Type |
Inspection |
| Activity Nr |
103191995 |
|
|
|
103192035
|
1032500
|
1987-02-11
|
601 NORTHWEST 21ST STREET, FRUITLAND, ID, 83619
|
|
| Inspection Type |
Complaint |
| Scope |
Partial |
| Safety/Health |
Safety |
| Close Conference |
1987-02-12 |
| Case Closed |
1987-03-02 |
Related Activity
| Type |
Complaint |
| Activity Nr |
71369797 |
| Safety |
Yes |
|
|
|
103191995
|
1032500
|
1987-02-11
|
601 NORTHWEST 21ST STREET, FRUITLAND, ID, 83619
|
|
| Inspection Type |
Complaint |
| Scope |
Partial |
| Safety/Health |
Health |
| Close Conference |
1987-05-27 |
| Case Closed |
1988-10-25 |
Related Activity
| Type |
Complaint |
| Activity Nr |
71369797 |
| Health |
Yes |
|
Violation Items
| Citation ID |
01001A |
| Citaton Type |
Serious |
| Standard Cited |
19100095 I02 I |
| Issuance Date |
1987-06-04 |
| Abatement Due Date |
1987-06-09 |
| Current Penalty |
210.0 |
| Initial Penalty |
420.0 |
| Nr Instances |
2 |
| Nr Exposed |
8 |
|
| Citation ID |
01001B |
| Citaton Type |
Serious |
| Standard Cited |
19100095 B01 |
| Issuance Date |
1987-06-04 |
| Abatement Due Date |
1988-06-10 |
| Nr Instances |
2 |
| Nr Exposed |
8 |
|
| Citation ID |
01002A |
| Citaton Type |
Other |
| Standard Cited |
19100134 B02 |
| Issuance Date |
1987-06-04 |
| Abatement Due Date |
1987-07-09 |
| Initial Penalty |
300.0 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| Related Event Code (REC) |
Complaint |
|
| Citation ID |
01002B |
| Citaton Type |
Other |
| Standard Cited |
19100134 E03 |
| Issuance Date |
1987-06-04 |
| Abatement Due Date |
1987-07-09 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| Related Event Code (REC) |
Complaint |
|
| Citation ID |
01002C |
| Citaton Type |
Other |
| Standard Cited |
19100134 F01 |
| Issuance Date |
1987-06-04 |
| Abatement Due Date |
1987-06-15 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| Related Event Code (REC) |
Complaint |
|
| Citation ID |
01002D |
| Citaton Type |
Other |
| Standard Cited |
19100134 F02 I |
| Issuance Date |
1987-06-04 |
| Abatement Due Date |
1987-06-15 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| Related Event Code (REC) |
Complaint |
|
| Citation ID |
01002E |
| Citaton Type |
Other |
| Standard Cited |
19100134 F05 II |
| Issuance Date |
1987-06-04 |
| Abatement Due Date |
1987-06-15 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| Related Event Code (REC) |
Complaint |
|
| Citation ID |
02001 |
| Citaton Type |
Other |
| Standard Cited |
19100095 G01 |
| Issuance Date |
1987-06-04 |
| Abatement Due Date |
1987-07-09 |
| Nr Instances |
6 |
| Nr Exposed |
23 |
|
| Citation ID |
02002 |
| Citaton Type |
Other |
| Standard Cited |
19100095 K01 |
| Issuance Date |
1987-06-04 |
| Abatement Due Date |
1987-07-09 |
| Nr Instances |
1 |
| Nr Exposed |
23 |
|
| Citation ID |
02003 |
| Citaton Type |
Other |
| Standard Cited |
19101200 E01 |
| Issuance Date |
1987-06-04 |
| Abatement Due Date |
1987-07-09 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
|
| Citation ID |
02004 |
| Citaton Type |
Other |
| Standard Cited |
19101200 E01 I |
| Issuance Date |
1987-06-04 |
| Abatement Due Date |
1987-07-09 |
| Nr Instances |
1 |
| Nr Exposed |
4 |
| Gravity |
03 |
| FTA Inspection NR |
17732652 |
| FTA Issuance Date |
1988-09-28 |
|
| Citation ID |
02005 |
| Citaton Type |
Other |
| Standard Cited |
19101200 F04 I |
| Issuance Date |
1987-06-04 |
| Abatement Due Date |
1987-06-23 |
| Nr Instances |
1 |
| Nr Exposed |
4 |
|
|
